MATERIAL SAFETY DATA SHEET

SECTION I - NAME & PRODUCT
ADDRESS: CONTACT:

 
TRADE NAME, COMMON NAME OR SPECIFICATION:

UV LENS CEMENT

 EMERGENCY TELEPHONE:
CHEMICAL FAMILY OR PRODUCT TYPE:

Ultraviolet Setting Cement

 APPROVED BY:

DATE:

SECTION II - COMPOSITION

CHEMICAL NAME

%

COMMON NAME

REG* Y/N

CAS #

OSHA PERMISSIBLE EXPOSURE LIMIT

ACGIH TLV

CARCINOGEN* Y/N
Mercaptan Ester       N/A NE NE N
               
 

 

              

*REGULATED AS PER LISTS: OSHA 29 CFR 1910, SUBPART Z: ACGIH, HHS/N TP, & IAPC

SECTION III - PHYSICAL AND CHEMICAL DATA
BOILING POINT: NA MELTING POINT: Liquid SPECIFIC GRAVITY (BULK): 1.2
VAPOR PRESSURE: N/A PERCENT VOLATILE BY VOL.: N/A VAPOR DENSITY: N/A
EVAPORATION RATE: N/A SOLUBILITY IN WATER: Insoluble SOLUBILITY IN ALCHOHOL:
SOLUBILITY IN OTHER SOLVENTS: APPEARANCE & ODOR: Clear liquid, sulforous odor

SECTION IV - FIRE & EXPLOSION HAZARD DATA
FLASH POINT: 175o C/350o F METHOD USED: FLAMMABLE LIMITS:
EXTINGUISHING MEDIA: Carbon Dioxide
SPECIAL FIRE FIGHTING PROCEDURES: Self Contained breathing apparatus

 

SECTION V - HEALTH HAZARD DATA
PRIMARY ROUTE(S) OF ENTRY: EFFECTS OF OVEREXPOSURE (EO) OR FIRST AID (FA):
INHALATION: Acute-shortness of breath, fainting, nausea & headaches.

 

 Remove to fresh air. Call a doctor
INGESTION:

 

 If swallowed, dilute with milk and water. Call a doctor.
SKIN: May cause dermatitis and skin rashes in areas of contact.

 

 Wash area with soap and water
EYE:

 

 Immediately wash with large amounts of water and occasionally lifting bottom and top eyelids. Call a doctor. Wear safety glass with side shields.
GENERAL FIRST AID:

 

 

SECTION VI - SPILL, LEAK & DISPOSAL
  1. Wipe up with absorbent material and rinse with non-polar solvent or polymerize with UV light and peel off.
  2. Waste Disposal Method: Cure to a solid with UV light. Cure material may be disposed of in landfill.
  3. Comply with Federal, state and local regulations.

SECTION VII - SPECIAL PROTECTION INFORMATION
  1. Use local exhaust
  2. Wear safety glasses with side shields
    3.
  3. Use impervious gloves (nitrile of butyl rubber)
  4. Contaminated Clothing: Wash before re-wearing

 

SECTION VIII - SPECIAL PRECAUTIONS & COMMENTS
  1. Parental guidance, supervision and participation required.
  2. UV light will burn and damage eyes, UV blocking safety glasses with side protection shields must be worn when working with lamp. Use only NIOSH approved safety glasses.
  3. Wear safety gloves when working with cement.

 

This Material Safety Data Sheet is offered solely for your information, consideration and investigation. It provides no warranties, either expressed or implied, and assumes no responsibility for the accuracy or completeness of the data contained herein.